Washing Raw Wool: Get Ready for Some Serious Suds

Some people groove on the idea of spinning raw wool straight from the sheep. Things might get a little messy, but that’s part of the fun of working with natural fibers — it's what we call spinning “in the grease."

But say you don’t want to deal with the hassle of spinning sticky wool. Or you want to use processing equipment like a drum carder . Or you’re just plain grossed out by the idea of getting "in the grease."

That's okay. I'm going to share my method for washing raw wool. Follow my tips and you can still feel proud of your DIY spirit.

Skirting Comes First

Before you wash your fleece, you need to skirt it. Skirting refers to removing very damaged, discolored or cut sections of the fleece. Every fleece is different, but even the cleanest fleeces from coated sheep have some not-so-great sections. High-quality fleeces for sale at a fiber festival or shop will have been skirted, but it’s always best to take a good look yourself.

Photo via Imperial Stock Ranch

Spread your fleece out on an old sheet or tarp and take a good look, picking out clumps of hay, burrs or manure. (You can’t get it all out at this stage!) Note that color variations in a fleece are normal, even desirable, but very yellowed or brittle sections should be removed. You can always set them aside and come back to it later to see if they can be salvaged for stuffing or other uses.

Hygiene Matters

Dirt and manure are a fact of life with raw wool, so don't wash fleece in the kitchen or anywhere else food is prepared. A laundry room, bathroom, garage or even outdoor space is better. If you’re using a household washing machine, be sure to clean it out well immediately afterwards by running a hot cycle with vinegar or laundry soap.

Avoid Felting

The number one rule of washing raw fleece: DON’T FELT IT!

You may think that hot water causes felting, but that's not completely true: It’s the agitation in hot water that causes fibers to stick and shrink. I like to use mesh lingerie bags (available in lots of places, including household and dollar stores) to protect the wool.

How to Wash Raw Wool

What You Need

  • Hot water
  • Laundry sink, large tub or top-loading washing machine
  • A few mesh lingerie bags
  • Dish soap (Dawn is great)
  • Rubber gloves (dishwashing gloves), reserved for fleece washing only
  • A sweater drying rack or a regular drying rack with an old sheet over it (to keep the shorter wool bits from falling through)

1. Soak the Wool

Fill up the sink or washer with HOT water and dish soap. The amount of soap depends on your fleece, but a few squirts per bagful is just fine. Swish the water and soap a bit to get it mixed, but only before you add the wool.

Wearing rubber gloves to protect your hands and arms, gently place a mesh bag or two of wool into the water. Hold them under the water without moving them around, until the wool is fully wet.

2. Let it Sit

Let the wool sit for about 30 minutes; the water will have cooled somewhat, but it should still be warm. If you let the wool sit in water that cools all the way, the lanolin will just re-deposit onto the fiber. The water will become quite dark and dirty!

3. Drain and Repeat

Drain the dirty water and refill with more hot water and another couple squirts of dish soap. Don’t let water run directly onto the wool! If you’re using a sink, you can push the mesh bags off to the side while you add more water, but with a washing machine you may need to gently lift the bags out into a washtub while you refill.

Place the bags back into the water and soak again. Depending on how dirty your fleece is, you might want to repeat steps 3 and 4.

4. Make Sure it's Bubble-Free

Refill with hot, clean water and soak to rinse out any bubbles.

5. Wring and Dry

If you’re using a washing machine, you can spin out the wool (as long as it doesn’t spray water into the wool while spinning!). Otherwise, gently press the bags of wool against the side or bottom of the sink so most of the water runs out. Don’t wring or twist the wool.

Now spread your nice clean wool out to dry; this process might take a few days, depending on the weather and humidity.

Photo via Laura Chau

How to wash locks

Washing individual clumps or locks of wool is a good way to work your way through fleece if you don’t have the space or inclination to wash it all at once. Follow the instructions above, but when you’re working with a small amount of wool at a time, you can use a sink or washing tub. If you can scoop out the locks with your (gloved) hands, you might not need to use a mesh bag, but it’s still good for extra safeguarding against felting. When in doubt, test-wash a small amount before jumping in!

January 16, 2019
More to Explore
Now Reading
Washing Raw Wool: Get Ready for Some Serious Suds